Россия +7 (495) 204-29-64
Казахстан +7 (727) 350-81-84

Описание

The continuous blowdown separators SP-1,5-0,8 is used for the separation of water and steam water mixture, which is formed from the purge water in steam boilers, drainage of steam and condensate from propranolol a drop in the pressure inside the boiler to the pressure in the separator, followed by heat consumption of steam and water.

These devices are also used in collection of condensate in order to reduce the consumption of steam and loss of heat are discharged with the steam and condensate mixture.

Lowest price in Russia: Moscow, Saint Petersburg, Novosibirsk, Yekaterinburg, Nizhny Novgorod, Kazan, Samara, Omsk, Chelyabinsk, Rostov-on-don, Ufa, Volgograd, Krasnoyarsk, Perm, Voronezh, Saratov, Krasnodar, Tolyatti, Barnaul, Ulyanovsk, Tyumen, Izhevsk, Irkutsk, Vladivostok, Yaroslavl, Khabarovsk, Makhachkala, Orenburg, Novokuznetsk, Tomsk, Kemerovo, Ryazan, Astrakhan, Penza, Naberezhnye Chelny, Lipetsk, Tula, Kirov, Cheboksary, Kaliningrad, Kursk, Ulan-Ude, Stavropol, Magnitogorsk, Yaroslavl, Ivanovo, Tver, Belgorod, Nizhniy Tagil, Arkhangelsk.

To buy in Kazakhstan separator airing in the following cities: Almaty, Shymkent, Karaganda, Taraz, Astana, Pavlodar, Ust-Kamenogorsk, Semipalatinsk, Aktobe, Uralsk, Kostanay, Petropavlovsk, Temirtau, Kyzylorda, Aktau, Atyrau, Ekibastuz.

Shipping at the best price in Belarus: Minsk, Gomel, Mogilev, Vitebsk, Grodno, Brest, Bobruisk, Baranovichi, Borisov, Orsha.

DEVICE

The separator is a vertical vessel welded structure, has a cylindrical shape, includes a body with a flat or elliptical bottoms, where the upper head joins to the body by means of flange connector.

In the upper part of the housing separator to the ring bolt simple separating device, i.e. the tangential inlet of the purge water (condensate), in addition also the installation of separators, which are used for drying steam, which again boils.

To middle part is welded to two or four supports for further installation of the separator onto the supporting beams.

In the lower part of the housing of the separator SP-1,5-0,8 is the receiving device destined for the reception of the purge water. This device consists of two shells that are installed concentric and two nozzles, tangentially welded to the hull.

If you disable the separator for the possibility of periodic cleaning of the lower portion of the water volume of dirt and sludge on the bottom, the bottom fitting is installed to divert water from the separator.

Also in the bottom case has a built-in fitting DN 150 float level controller, whose task is to automatically support a constant level of treated water.

Separators equipped with vodorazdelny device that includes vodorazdelnoye glass and the faucet or valve that allows you to monitor the level of treated water.

For the separator SP-1,5-0,8 establishes a pressure gauge (showing measurements with a limit of up to 1.6 MPa (16 kgf/cm2), which includes the venting three-way valve and bleed valve), which allows you to monitor the level of working pressure in the steam space of the device.

In the separator SP-1,5-0,8 working pressure is set either depending on atmospheric pressure for the discharge of steam into the atmosphere or based on the amount of total loss resistance of the steam-discharge piping and pressure equipment, where steam is supplied directly from the separator.

The cutoff above the permissible steam pressure in the housing is ensured by established safety valve (full-lift flanged DN 50 PN 16 kgs/cm2), equipped with a replaceable spring (type I), which is open only at a pressure in the range of 7 kgf/cm2 to 13 kgf/cm2. The upper part of the valve is covered with a cap, which has a special adjusting screw provided to install the spring set pressure.

 

THE PRINCIPLE OF OPERATION

The principle of operation of the separator continuous blowdown is divided into several stages:

- receive steam-water mixture from the boiler;

- the separation of this mixture to water and steam due to the rotational movement and expansion of the flow in the receiving device;

next, in the receiving device is the receiving operation;

- the final susiana couple in a separation device.

Характеристики

Характеристика СП 1,5-0,8Значение
 Наименование сепаратора  Сепаратор Ду800 
 Рабочее давление, МПа  0,78
 Температура рабочая, не более   175
 Давление пробное при гидроиспытании, МПа   1,1
 Производительность, т/ч  3,75
 Расход пароводяной смеси, т/ч  15,75
 Вместимость, м3  1,5
 Масса, кг  1200

Документация

ГОСТы и сертификаты

Фотогалерея

Comments ()

    The continuous blowdown separator SP-1,5-0,8

    These devices are also used in collection of condensate in order to reduce the consumption of steam and loss of heat are discharged with the steam and condensate mixture.
    Документация

    319 400 руб.
    Все цены указаны с учетом НДС 20%
    - +
    Поделиться:

    Просмотренные товары